Workers were on scene to clean up the oil spill in Abbotsford at Trans Mountain Pipeline’s Sumas pump station in June 2020. (File photo by Shane MacKichan)

Workers were on scene to clean up the oil spill in Abbotsford at Trans Mountain Pipeline’s Sumas pump station in June 2020. (File photo by Shane MacKichan)

TSB releases final report on June 2020 oil spill in Abbotsford

Transportation Safety Board says pipeline fitting to blame for spill of up to 190K litres

A one-inch pipeline fitting has been identified as the source of a crude-oil spill last June at Trans Mountain Pipeline’s Sumas pump station in Abbotsford.

The Transportation Safety Board (TSB) of Canada on Tuesday (April 13) released the findings of its final report into the matter.

The report states that the spill – amounting to 150,000 to 190,000 litres – resulted when a one-inch compression fitting separated from tubing on a section of above-ground piping adjacent to the building that houses the “equation of state” (EOS) system.

“The failed compression fitting was used to join tubing from the discharged mainline to the EOS system,” the report states.

“From the point of release, the oil had followed a path into the pump station’s surface drainage system, through an oil-water separator, and into a culvert that discharges surface water into the south section of the property.”

As a result, 7,000 litres of the oil migrated to the agricultural field in the south section, the TSB said.

RELATED: B.C. Indigenous leaders speak out after 150,000 litres of oil spill in Abbotsford

RELATED: Inclusion of Indigenous reps after a spill part of ‘reconciliation’: Suzuki Foundation

The agency said that during the site cleanup, approximately 143,000 litres of the product was recovered, including about 6,600 litres from the south section.

The TSB said the compression fitting was installed in 2015, using the manufacturer’s instructions.

The fitting was tested in December 2015 and was found to have no leaks, the report indicates.

On the day of the spill – June 12, 2020 – alarms were triggered to indicate that a spill had occurred, and an automatic-shutdown process began, the report states.

However, the valves required to isolate the section of tubing in question were manual and were not part of this process. They remained open until Trans Mountain personnel were able to safely enter the site about five hours after the alarm sounded, the report indicates.

Meanwhile, the oil releasing from the EOS system reached the oil-water separator and continued to accumulate until it could not longer be trapped effectively, the TSB said.

The separator does not have an automated isolation system or manual valves.

“Therefore, once oil began flowing into the agricultural field, there was no means to stop it until operators could isolate the source of the release on the EOS system.”

The report states that once the source of the leak was established, Trans Mountain placed vacuum trucks at the oil-water separator and along the fence line separating the north and south sections of the property.

Site remediation started the following day, and included excavating the affected soils and recovering the free product from the groundwater, the report adds.

The TSB said a “multi-year remediation plan” was developed for contaminants that could not be removed from the site.

“The most appropriate remediation methods will be selected and implemented based on the results of continued monitoring and testing of the soil and groundwater.”

The TSB said the Canada Energy Regulator conducted emergency management of the site, did field inspections, and has monitored the progress of remediation activities.

The report says the actions taken by Trans Mountain have included developing a procedure to verify the integrity of the existing tubing systems and adding an automated isolation valve on the inlet of the EOS tubing system and a check valve on the inlet.

The company has also agreed to complete upgrades to the Sumas pump station by this summer, including containment and drainage features, a new oil-water separator, and a line containment area around the above-ground piping.

The report says Trans Mountain will also develop an internal standard for the construction and quality assurance of new tubing systems, as well as a procedure for their installation.

The Trans Mountain Pipeline transports petroleum crude oil and refined petroleum products from Edmonton to refineries and terminals in B.C. and Washington state.

Previous spills at the Abbotsford site took place in 2005, involving 210,000 litres, and in 2012, involving 90,000 litres.

RELATED: Delayed response impacted oil spill, says report



vhopes@abbynews.com

Like us on Facebook and follow us on Twitter

EnvironmentTrans Mountain pipeline

Get local stories you won't find anywhere else right to your inbox.
Sign up here

 

The Transportation Safety Board has concluded that a June 2020 oil spill at the Sumas pump station in Abbotsford was the result of a one-inch compression fitting separating from tubing on a section of above-ground piping. (Photo: Transportation Safety Board)

The Transportation Safety Board has concluded that a June 2020 oil spill at the Sumas pump station in Abbotsford was the result of a one-inch compression fitting separating from tubing on a section of above-ground piping. (Photo: Transportation Safety Board)

Just Posted

Elias Pettersson and the Vancouver Canucks drew a large crowd to the Abbotsford Centre in 2019. Canucks management hopes the crowds return for the planned AHL team this fall, and early returns are positive. (John Morrow/Abbotsford News)
Canucks: ‘Incredible’ early interest for Abbotsford AHL tickets

Team has had a strong response to both e-mail information and priority ticket lists

Red dot shows location where fisherman was rescued by boater on Friday, May 7, 2021. Other fisher still missing presumed drowned after boat swamped on Fraser River near Vedder/Sumas confluence. Rescued man swam to shore after boat sank, while friend is still classified as missing as of May 10. (City of Chilliwack map)
Fisherman still missing after boat flipped on the Fraser River

One man made it out, other still missing, after anchor got snagged in the Fraser near Chilliwack

Graduating goalie Mathieu Caron stops Prince George forward Nick Rheaume in Sunday’s season finale at the Chilliwack Coliseum. (Darren Francis photo)
Chilliwack Chiefs say goodbye to departing vets in pod season finale

Longtime goalie Mathieu Caron and captain Kyle Penney are among the players aging out of the BCHL

Kent-Harrison Search and Rescue workers and emergency personnel set up a command centre on Friday evening. It took KHSAR to find a lost hiker who veered off-course near Campbell Lake west of Harrison Hot Springs, finding them about 380 metres off-trai and escorted them safely to the trailhead. (Photo/Kent-Harrison Search and Rescue)
Kent-Harrison Search and Rescue guides lost hiker home

Hiker ended up almost 400 metres off-course as darkness fell on May 7

Joan Septembre went for a weekend hike at Lindeman Lake, parking next to a vehicle that had two windows smashed in. (submitted photo)
Thieves active at Lindeman Lake and other parking spots along Chilliwack Lake Road

The hiking community is lamenting an uptick in car theft and vandalism as the weather gets nicer

A bullet hole is seen in the windshield of an RCMP vehicle approximately 4 km from Vancouver International Airport after a one person was killed during a shooting outside the international departures terminal at the airport, in Richmond, B.C., Sunday, May 9, 2021. THE CANADIAN PRESS/Darryl Dyck
Homicide team IDs man in fatal YVR shooting as police grapple with spate of gang violence

Man, 20, charged in separate fatal shooting Burnaby over the weekend

RCMP are searching for Philip Toner, who is a ‘person of interest’ in the investigation of a suspicious death in Kootenay National Park last week. Photo courtesy BC RCMP.
RCMP identify ‘person of interest’ in Kootenay National Park suspicious death

Police are looking for Philip Toner, who was known to a woman found dead near Radium last week

Vancouver Canucks goaltender Thatcher Demko (35) makes a save on Winnipeg Jets’ Nate Thompson (11) during second period NHL action in Winnipeg, Monday, May 10, 2021. THE CANADIAN PRESS/Fred Greenslade
Vancouver Canucks see NHL playoff hopes dashed despite 3-1 win over Winnipeg

Montreal Canadiens earn final North Division post-season spot

The B.C. legislature went from 85 seats to 87 before the 2017 election, causing a reorganization with curved rows and new desks squeezed in at the back. The next electoral boundary review could see another six seats added. (Black Press files)
B.C. election law could add six seats, remove rural protection

North, Kootenays could lose seats as cities gain more

The Independent Investigations Office of B.C. is investigating the shooting of an Indigenous woman in the Ucluelet First Nation community of Hitacu. (Black Press Media file photo)
B.C. First Nation wants ‘massive change’ after its 3rd police shooting in less than a year

Nuu-chah-nulth woman recovering from gunshot wounds in weekend incident near Ucluelet

Join Black Press Media and Do Some Good
Join Black Press Media and Do Some Good

Pay it Forward program supports local businesses in their community giving

Cannabis bought in British Columbia (Ashley Wadhwani/Black Press Media)
Is it time to start thinking about greener ways to package cannabis?

Packaging suppliers are still figuring eco-friendly and affordable packaging options that fit the mandates of Cannabis Regulations

Nurse Gurinder Rai, left, administers the Moderna COVID-19 vaccine to Maria Yule at a Fraser Health drive-thru vaccination site, in Coquitlam, B.C., on Wednesday, May 5, 2021. The site is open for vaccinations 11 hours per day to those who have pre-booked an appointment. THE CANADIAN PRESS/Darryl Dyck
COVID vaccine bookings to open for adults 40+, or 18+ in hotspots, across B.C.

Only people who have registered will get their alert to book

Most Read