West Fraser lumber. File photo.

West Fraser lumber. File photo.

Worker buried in sawdust in a shavings bin at West Fraser B.C. Sawmill

WorksafeBC said rescue was needed on one occasion as the worker was unable to help themself

A worker at the Chasm Sawmill division of West Fraser was buried to about head or chest depth in a wood shavings bin area and needed to be rescued, according to a WorkSafeBC report.

“A worker performing clean up during maintenance type work inside a bin approximately 50 to 80 feet high, 30 feet wide, was engulfed by sawdust and/or wood shavings type recovery waste product,” according to the report. “The need for rescue did arise and the lone worker was engulfed and unable to self-rescue.”

The incident was not immediately reported to the board and between the time of the worker being buried and the conclusion of the full investigation, work resumed.

“This employer did not immediately undertake a preliminary investigation that identified all the unsafe conditions, acts or procedures as far as possible, in order to ensure that work can be continued or resumed,” according to the report. “Also, according to information provided by the employer, another worker was engulfed; however, that worker managed to self-rescue.”

The report notes that West Fraser failed to ensure adequate protection from entrapment or engulfment, a serious health and/or safety hazard.

The worker who entered the wood shavings recovery type bin, “was not provided with and did not wear a lifeline and harness, and was not continuously tended by a standby person who is equipped for and capable of effecting immediate rescue.”

WorkSafeBC was notified approximately one week later during a routine inspection, according to the report.

“This employer failed to ensure the scene of an accident that is reportable under subsection (1) was not disturbed, to permit investigate, and prevent potential injuries or death, and any other worker(s) being engulfed.”

A preliminary investigation report was completed and provided to a WorkSafeBC officer. West Fraser has since developed and performed a risk assessment, developed a safe work procedure for entering the shavings bin and as of Nov. 21 planned an emergency drill for confined space and/or enclosed space within the next 30 days.

Part of the actions includes no entry into the bin unless the material is four feet or less.

“A Vac truck and hose system will be used from outside the bin when materials are greater than four feet.”

The 100 Mile Free Press has contacted West Fraser but has not yet received a response.


newsroom@100milefreepress.net

Like us on Facebook and follow us on Twitter.

Get local stories you won't find anywhere else right to your inbox.
Sign up here

Just Posted

Russell Jonathon George Gurney was last seen in Chilliwack in mid-December. (RCMP photo)
RCMP ask for help to find missing Abbotsford man last seen in Chilliwack

Police and family are concerned for the well-being of Russell Jonathon George Gurney

The Harrison Hot Springs village office, as seen from the back. (Grace Kennedy/The Observer)
Harrison village staff to get additional office space

The village has agreed to spend up to $75,000 of the COVID-19 Safe Restart Grant on a new portable

Harrison Hot Springs kindergarten students held a peaceful protest Monday (Jan. 18) to end separated recess. The protest was inspired by Martin Luther King Jr. and his lessons of non-violent action. Check out page XX for the whole story. (Dustin Neufeld/Contributed)
PHOTOS: Harrison students launch peaceful protest against playground division for MLK day

The kindergarten students negotiated with the school principal to enable recess on both playgrounds

Ottawa serial killer Camille Joseph Cleroux died of natural causes at Abbotsford’s Pacific Institution on Sunday.
Serial killer housed at Abbotsford’s Pacific Institution dies of natural causes

Camille Joseph Cleroux announced dead on Sunday, known as notorious Ottawa serial killer

Maj.-Gen. Dany Fortin, vice-president of logistics and operations at the Public Health Agency of Canada, speaks at a news conference on the COVID-19 pandemic in Ottawa, on Friday, Jan. 15, 2021. THE CANADIAN PRESS/Justin Tang
B.C. records 500 new COVID-19 cases Wednesday, 14 deaths

Outbreak at Surrey Pretrial jail, two more in health care

Vancouver Canucks’ Travis Hamonic grabs Montreal Canadiens’ Josh Anderson by the face during first period NHL action in Vancouver, Wednesday, Jan. 20, 2021. THE CANADIAN PRESS/Jonathan Hayward
Horvat scores winner as Canucks dump Habs 6-5 in shootout thriller

Vancouver and Montreal clash again Thursday night

A woman writes a message on a memorial mural wall by street artist James “Smokey Devil” Hardy during a memorial to remember victims of illicit drug overdose deaths on International Overdose Awareness Day, in the Downtown Eastside of Vancouver, on Monday, August 31, 2020. THE CANADIAN PRESS/Darryl Dyck
B.C. paramedics respond to record-breaking number of overdose calls in 2020

On the front lines, COVID-19 has not only led to more calls, but increased the complexity

Eighteen-year-old Aidan Webber died in a marine accident in 2019. He was a Canadian Junior BMX champion from Nanaimo. (Submitted)
Inadequate safety training a factor in teen BMX star’s workplace death in 2019

Aidan Webber was crushed by a barge at a fish farm near Port Hardy

Southern resident killer whales in B.C. waters. Research shows the population’s females are more negatively influenced by vessel traffic than males. (Photo supplied by Ocean Wise Conservation Association)
Female orcas less likely to feed in presence of vessel traffic: study

Research the southern resident population raises concerns over reproduction capacity

Join Black Press Media and Do Some Good
Join Black Press Media and Do Some Good

Pay it Forward program supports local businesses in their community giving

Cannabis bought in British Columbia (Ashley Wadhwani/Black Press Media)
Is it time to start thinking about greener ways to package cannabis?

Packaging suppliers are still figuring eco-friendly and affordable packaging options that fit the mandates of Cannabis Regulations

(Black Press Media files)
Transport Canada not budging on enclosed deck rules, despite calls from BC Ferries union

There have been at least 23 cases of the U.K. variant detected in Canada, four of which are in B.C.

The Elk Valley Hospital is adapting to meet the needs of patients in the Elk Valley.
1-in-5 COVID tests coming back positive in and around Fernie, sparking concern

Dr Ron Clark of Elk Valley Hospital said one in five tests was returning positive for COVID-19

Most Read